OPTIMIZATION OF RACING SERIES HYBRID ELECTRIC VEHICLE USING DYNAMIC PROGRAMMING

Authors

  • Zainab Asus Faculty of Mechanical Engineering, Universiti Teknologi Malaysia, 81310 UTM, Johor, Malaysia
  • El-Hassane Aglzim DRIVE Laboratory, Institut Supérieur de l’Automobile et des Transports (ISAT), University of Burgundy, 49 rue Mlle Bourgeois, 58027 Nevers, France.
  • Daniela Chrenko DRIVE Laboratory, Institut Supérieur de l’Automobile et des Transports (ISAT), University of Burgundy, 49 rue Mlle Bourgeois, 58027 Nevers, France.
  • Zul-Hilmi Che-Daud Faculty of Mechanical Engineering, Universiti Teknologi Malaysia, 81310 UTM, Johor, Malaysia
  • Luis Le-Moyne DRIVE Laboratory, Institut Supérieur de l’Automobile et des Transports (ISAT), University of Burgundy, 49 rue Mlle Bourgeois, 58027 Nevers, France.

Keywords:

racing car, series hybrid electric vehicle, engine/battery, dynamic programming optimization

Abstract

This paper discusses modeling of a racing series hybrid electric vehicle called Noao. This plug-in hybrid system is equipped with an engine/generator set as its range extender. The battery acts as the prime mover to propel the vehicle. Available applications of control strategies for hybrid vehicle system in the literature are reviewed to identify a suitable solution for its optimization. The behavior of the system and all of its components are modeled in simulation and validated through experiments performed on the real racing circuit. A dynamic programming approach is applied offline to optimize the existing rule based control parameters defined for this racing car application. The same approach is implemented to adjust the engine operating point in order to achieve a longer endurance and to have a better performance.

References

C.C. Lin, et al., Integrated, Feed-Forward Hybrid Electric Vehicle Simulation in SIMULINK and its Use for Power Management Studies, SAE Paper no. 2001-01- 1334 (2001).

L. Serrao, S. Onori, and G. Rizzoni, A Comparative Analysis of Energy Management Strategies for Hybrid Electric Vehicles, Journal of Dynamic Systems, Measurement, and Control 133 (3) (2011).

J.P. Gao, G.M.G. Zhu, E.G. Strangas, and F.C. Sun, Equivalent fuel consumption optimal control of a series hybrid electric vehicle, Journal of Automobile Engineering 8 (223) (2009) 1003-1018.

S.G. Wirasingha and A. Emadi, Classification and Review of Control Strategies for Plug-In Hybrid Electric Vehicles, IEEE Transactions on Vehicular Technology 60(1) (2011) 111-122.

F.R. Salmasi, Control Strategies for Hybrid Electric Vehicles: Evolution, Classification, Comparison, and Future Trends, IEEE Transactions on Vehicular Technology 56(5) (2007) 2393-2404.

J. Park, Y. Park, and J.H. Park, Real-Time Powertrain Control Strategy for SeriesParallel Hybrid Electric Vehicles, SAE Technical Paper Series no. 2007-01-3472 (2007) 1-9.

Pôle de la performance de Nevers Magny-Cours. Noao, vehicule electrique avec prolongateur d'autonomie. Pole de la performance de Nevers Magny-Cours. Available from: http://www.asso-ppnmc.fr [accessed 15 March 2013]

Magny-Cours International Circuit. Pistes et pilotage, Presentation de la Piste Grand Prix. Available from: http://www.circuitmagnycours.com [accessed 5 February 2013]

C.C. Lin, H. Peng, J.W. Grizzle, and J.M. Kang, Power Management Strategy for a Parallel Hybrid Electric Truck, IEEE Transactions on Control Systems Technology 11(6) (2003) 839-850.

D. Ambühl and L. Guzzella, Predictive Reference Signal Generator for Hybrid Electric Vehicles, IEEE Transactions on Vehicular Technology 58(9) (2009) 4730- 4740.

O. Sundstrom and L. Guzzella, A Generic Dynamic Programming Matlab Function, in 18th IEEE International Conference on Control Applications, Saint Petersburg,

Russia, Jul. 2009, pp. 1625-1630.

M. Koot, et al., Energy Management Strategies for Vehicular Electric Power Systems, IEEE Transactions on Vehicular Technology 54(3) (2005) 771-782.

R. Langari and J.S. Won, Intelligent Energy Management Agent for a Parallel Hybrid Vehicle-Part I: System Architecture and Design of the Driving Situation Identification Process, IEEE Transactions on Vehicular Technology 54(3) (2005) 925-934.

Q. Gong, Y. Li, and Z.R. Peng, Trip Based Optimal Power Management of Plug-in Hybrid Electric Vehicles Using Gas-Kinetic Traffic Flow Model, IEEE Transactions on Vehicular Technology 57(6) (2008) 3393-3401.

K.C. Bayindir, M.A. Gozukucuk, and A. Teke, A comprehensive overview of hybrid electric vehicle: Powertrain configurations, powertrain control techniques and electronic control units, Energy Conversion and Management 52(2) (2011)

-1313.

A. Sciarretta, M. Back, and L. Guzzella, Optimal Control of Parallel Hybrid Electric Vehicles, IEEE Transactions on Control Systems Technology 12(3) (2004) 352-363.

O. Sundstrom, L. Guzzella, and P. Soltic, Optimal Hybridization in Two Parallel Hybrid Electric Vehicles using Dynamic Programming, in The International Federation of Automatic Control, Jul. 2008.

C.E. Nino-Baron, A.R. Tariq, G. Zhu, and E.G. Strangas, Trajectory Optimization for the Engine-Generator Operation of a Series Hybrid Electric Vehicle, IEEE Transactions on Vehicular Technology 60(6) (2011) 2438-2447.

S. Delprat, J. Lauber, T.M. Guerra, and J. Rimaux, Control of a Parallel Hybrid Powertrain: Optimal Control, IEEE Transactions on Vehicular Technology 53(3) (2004) 872-881.

D.V. Ngo, T. Hofman, M. Steinbuch, and A.F.A. Serrarens, An Optimal ControlBased Algorithm for Hybrid Electric Vehicle using Preview Route Information, in American Control Conference, Baltimore, USA, June 2010, pp. 5818-5823.

B. Geng, J.K. Mills, and D. Sun, Energy Management Control of Microturbine Powered Plug-In Hybrid Electric Vehicles Using Telemetry Equivalent Consumption Minimization Strategy, IEEE Transactions on Vehicular Technology 60(9) (2011) 4238-4248.

V. Sezer, M. Gokasan, and S. Bogosyan, A Novel ECMS and Combined Cost Map Approach for High-Efficiency Series Hybrid Electric Vehicles, IEEE Transactions on Vehicular Technology 60(8) (2011) 3557-3570.

L. Guzella and A. Sciarretta, Vehicle Propulsion Systems, second ed., Springer, Zurich, Switzerland, 2007.

K.L. Butler, M. Ehsani, and P. Kamath, A Matlab-Based Modeling and Simulation Package for Electric and Hybrid Electric Vehicle Design, IEEE Transactions on Vehicular Technology 48(6) (1999) 1770-1778.

G. Rizzoni, L. Guzzella, and B.M. Baumann, Unified Modeling of Hybrid Electric Vehicle Drivetrains, IEEE/ASME Transactions on Mechatronics 4(3) (1999) 246- 257.

M. Ehsani, Y. Gao, S.E. Gay, and A. Emadi, Modern Electric, Hybrid Electric, and Fuel Cell Vehicles: Fundamentals, Theory, and Design. CRC Press, Texas, US, 2004.

J. Liu and H. Peng, Modeling and Control of a Power-Split Hybrid Vehicle, IEEE Transactions on Control Systems Technology 16(6) (2008) 1242-1251.

A. Konev and L. Lezhnev, Control Strategy Optimization for a Series Hybrid Vehicle, SAE Technical Paper Series no. 2006-01-0663 (2006).

S.J. Moura, H.K. Fathy, D.S. Callaway, and J.L. Stein, A Stochastic Optimal Control Approach for Power Management in Plug-In Hybrid Electric Vehicles, IEEE Transactions on Control Systems Technology 19(3) (2011) 545-555.

Z. Asus, D. Chrenko, E.H. Aglzim, A. Keromnes, and L. Le-Moyne, Simple method of estimating consumption of internal combustion engine for hybrid application, in IEEE Transportation Electrification Conference and Expo (iTEC), Michigan, USA, June 2012.

D.F. Opila, et al., An Energy Management Controller to Optimally Trade Off Fuel Economy and Drivability for Hybrid Vehicles, IEEE Transactions on Control Systems Technology 99 (2011) 1-16.

Q. Gong, Y. Li, and Z.R. Peng, Trip Based Power Management of Plug-in Hybrid Electric Vehicle with Two-Scale Dynamic Programming, in IEEE Vehicle Power and Propulsion Conference, Sep. 2007, pp. 12-19.

Q. Gong, Y. Li, and Z. Peng, Power Management of Plug-in Hybrid Electric Vehicles Using Neural Network Based Trip Modeling, in American Control Conference, Jun. 2009, pp. 4601-4606.

C.C. Lin, H. Peng, and J.W. Grizzle, A Stochastic Control Strategy for Hybrid Electric Vehicles, in American Control Conference, vol. 5, Jul. 2004, pp. 4710- 4715.

J.F. Bonnans, et al., Parametric Optimization of Hybrid Car Engines, Optimisation and Engineering 5(4) (2004) 395-415.

A. Brahma, Y. Guezennec, and G. Rizzoni, Optimal Energy Management in Series Hybrid Electric Vehicles, in American Control Conference, vol. 1, Sep. 2000, pp. 60-64.

L.V. Perez, G.R. Bossio, D. Moitre, and G.O. Garcia, Optimization of power management in an hybrid electric vehicle using dynamic programming, Mathematics and Computers in Simulation 73 (2006) 244–254.

A. Sciarretta and L. Guzzella, Control of Hybrid Electric Vehicles: Optimal Energy Management Strategies, IEEE Control Systems Magazine 27(2) (2007) 60-70.

L. Guzzella and C.H. Onder, Introduction to Modeling and Control of Internal Combustion Engine Systems, second ed., Springer, Zurich, Switzerland, 2009.

Downloads

Published

2018-04-01

How to Cite

Asus, Z., Aglzim, E.-H., Chrenko, D., Che-Daud, Z.-H., & Le-Moyne, L. (2018). OPTIMIZATION OF RACING SERIES HYBRID ELECTRIC VEHICLE USING DYNAMIC PROGRAMMING. Jurnal Mekanikal, 38(1). Retrieved from https://jurnalmekanikal.utm.my/index.php/jurnalmekanikal/article/view/34

Issue

Vol 38: June 2015

Section

Mechanical

License

Copyright of articles that appear in Jurnal Mekanikal belongs exclusively to Penerbit Universiti Teknologi Malaysia (Penerbit UTM Press). This copyright covers the rights to reproduce the article, including reprints, electronic reproductions or any other reproductions of similar nature.

Similar Articles

<< < 7 8 9 10 11 12 13 > >> 

You may also start an advanced similarity search for this article.